D88尊龙

你好,歡迎來到濟南D88尊龙環能燃氣發電設備有限公司官方網站!

發電機組的定期維護哪些部位是必要的?

來源:http://dgxcbw.com   發布于:2019-06-10

D88尊龙1、 機組起動電瓶毛病   電瓶長時間無人維護,電解液水分揮發后得不到及時補充,沒有配置起動電瓶充電器,電瓶長時間自然放電后電量降低,或所運用的充電器需求人工定期停止均充浮充倒換,由于忽略未停止倒換操作致使電瓶電量達不到請求,處理此問題除了配置高質量充電器外,必要的檢測維護是必需的。

1. The defective batteries of unit start-up batteries are not maintained for a long time, the water in the electrolyte can not be added in time after volatilization, the batteries charger is not equipped, the battery capacity decreases after natural discharge for a long time, or the demand of the charger used is periodically stopped by manual, and the battery capacity can not reach the request due to neglect of the non-stop replacement operation, so this problem can be solved. In addition to equipping high quality chargers, necessary inspection and maintenance are necessary.

2、 水進入柴油機   由于空氣中水氣在溫度的變化發作冷凝現象,結成水珠掛附在油箱內壁,流入柴油,致使柴油含水量超標,這樣的柴油進入發起機高壓油泵,會銹蝕精細耦合件-----柱塞,嚴重的會損壞機組,定期維護即有效可防止。

QQ截圖20171025151947.jpg

2. Water enters diesel engine because of the condensation phenomenon of water vapor in the air due to the change of temperature. Water droplets are attached to the inner wall of the tank and flow into diesel oil, which results in excess of water content of diesel oil. Such diesel oil enters the high-pressure oil pump of the initiator, which will corrode the fine coupling component, plunger, and seriously damage the unit. Regular maintenance can effectively prevent it.

D88尊龙3、 機油的堅持期(二年)   發起機的機油是機械光滑作用,而機油也有一定的堅持期,長時間寄存,機油的物理化學性能會發作變化,形成機組工作時光滑情況惡化,容易引發機組零件損壞,所以光滑油要定期改換。

D88尊龙3. The sticking period of the engine oil (two years) is the mechanical smoothing effect of the engine oil, and the engine oil also has a certain sticking period, long time storage, the physical and chemical properties of the engine oil will change, resulting in the deterioration of the smooth working condition of the unit, easy to cause damage to the parts of the unit, so the smooth oil should be changed regularly.

D88尊龙4、 三濾的改換周期(柴濾、機濾、空濾、水濾)   濾器是起到對柴油、機油或水過濾作用的,以防雜質進入機體內,而在柴油中油污、雜質也是不可防止的存在,所以在機組運轉過程中,過濾器就起到了重要作用,但同時這些油污或雜質也就被堆積在濾網壁上而使濾器過濾才能降落,堆積過多,油路將無法暢通,這樣油機帶載運轉時將會因油無法供應而休克(好像人缺氧),所以正常發電機組在運用過程中,我們倡議:第一、常用機組每500 小時改換三濾;第二、備用機組每二年改換三濾; 天匯"電管家"專業配電室運維托管

4. The replacement cycle of the three filters (wood filter, machine filter, air filter and water filter) is to filter diesel oil, oil or water in order to prevent impurities from entering the body. Oil pollution and impurities in diesel oil are also unavoidable. Therefore, the filter plays an important role in the operation of the unit, but at the same time, these oil pollution or impurities are accumulated on the screen wall to make the filter. The filter can only land, accumulate too much, and the oil pipeline will not be smooth, so the oil machine will be shocked by the lack of supply of oil (like people lack oxygen) when it is running on load, so in the operation of normal generating units, we propose that: first, three filters should be replaced every 500 hours for common units; second, three filters should be replaced every two years for standby units; and the operation and maintenance trusteeship of Tianhui Electric Housekeeper's professional distribution room.

D88尊龙5、 冷卻系統   水泵、水箱及輸水管道長時間未作清洗,使水循環不暢,冷卻效果降落,水管接頭能否良好、水箱、水道能否有漏水等,假如冷卻系統有毛病,招致的結果有:第一、冷卻效果不好而使機組內水溫過高而停機,威爾信機組最常見;第二、水箱漏水而使水箱內水位降落,機組也會無法正常工作(為避免在冬季運用發電機時,水管凍結,我們倡議最好在冷卻系統中裝置水加熱器)。

5. Cooling system pumps, water tanks and water pipelines have not been cleaned for a long time, which makes water circulation not smooth, cooling effect drops, water pipe joints can be good, water tanks, water pipelines can leak, and so on. If there are problems in the cooling system, the results are as follows: first, the cooling effect is not good and the water temperature in the unit is too high and shuts down, Wilson unit is the most common; second, water tank leaks and causes. When the water level in the water tank falls, the unit will also be unable to work properly (in order to avoid the freezing of water pipes when using generators in winter, we recommend that water heaters be installed in the cooling system).

以上就是今天小編為大家介紹關于瓦斯發電機組的相關的資訊,您可以及時的關注我們的網址:http://dgxcbw.comD88尊龙了解更多的詳情咨詢,我們會有更多的精彩內容為您呈現.

Above is today's edition to introduce the relevant information about gas generating units, you can timely pay attention to our website: http://dgxcbw.com for more detailed consultation, we will have more wonderful content for you to present.


上一篇:發電機組的使用對于各種媒介使用要求
下一篇: 燃氣發電機組出現燒瓦的情況與什么有關?