D88尊龙

你好,歡迎來到濟南D88尊龙環能燃氣發電設備有限公司官方網站!

柴油發電機組進水該如何處理

來源:http://dgxcbw.comD88尊龙   發布于:2017-06-02

D88尊龙 夏季雨水較多,柴油發電機組如果沒有做好充分的防水措施,則會導致雨水從煙管進入發動機缸體或發電球中,影響機組的運作和使用壽命。因此當機組進水,應及時采取如下相應措施:

Summer rain is more, if there is no diesel generating set well waterproof measures, will cause the rain from the pipe into the engine cylinder block or power ball, affect the operation and service life of the unit. Therefore, when the unit is flooded, the following measures should be taken as follows: 

D88尊龙  1、當發現發電機進水,如果發電機組在運行就立刻關機,在停機狀態則不允許開機。

When the generator is in the water, if the generator is running, it will be turned off immediately. 

  2、將柴油發電機組的一邊用硬物支撐起來抬高,使發動機油底殼放油部位處于低位置,旋下放油螺塞,拔出油標尺,使油底殼內的水自行流出。當流至剛要放出機油時應略讓機油和水一起放出一部分后旋上放油螺塞。

2, will prop up one side of the diesel generator set with hard objects, make the engine oil sump oil drain parts in the lowest position, spin down the oil plug, pull out the oil scale, make themselves out of the water in the oil sump. When the flow of oil is to be released, the oil and water should be released a little bit to release the oil screw. 

  3、拆下空氣濾清器,換下新的濾芯并且用油浸。

D88尊龙Remove the air filter, replace the new filter and soak in oil. 

燃氣發電機組

  4、下面拆卸下進、排氣管及消聲器,排除掉管內的水。打開減壓,搖轉柴油機發電,觀察進、排氣口是否有水排出,若有水排出則繼續搖轉曲軸,至氣缸內的水全部排凈。裝上進、排氣管及消聲器,在進氣口加入少許機油,搖轉曲軸數圈,然后裝上空氣濾清器。

Remove the incoming, exhaust pipe and silencer, and remove the water from the tube. Open decompression, rocking-turn diesel power generation, observe whether there is water inlet and outlet, if there is water continues to turn the crankshaft, net to all of the water in the cylinder. Fill in, exhaust pipe and muffler, add a little oil to the inlet, roll the crank shaft several times, then install air filter. 

  5、拆下油箱,將其中的油、水全部放凈,檢查燃油系統是否存在水,并且排凈。

Remove the fuel tank, remove all the oil and water, check for water and drain the fuel system. 

  6、放出水箱及水道內的污水,清洗水道,加入清潔的河水或煮沸后的井水至水浮子升起。打開油門開關,起動柴油機。柴油機起動后要注意觀察機油指示器升起情況,傾聽柴油機有無異常響聲。

D88尊龙Discharge water from water tanks and waterways, clean waterways, add clean water or boil water to the water float. Turn on the throttle switch and start the diesel engine. When the diesel engine starts up, watch the engine oil indicator rise and listen to the engine without any noise. 

  7、拆開發電機,檢查發電機內部的定子和轉子,然后烘干后再裝配。

Disassemble the generator, check the stator and rotor inside the generator and then reassemble after drying. 

我公司會恪守商業信譽及平等互利的原則,竭誠為用戶提供優良的服務,創作更加完美的作品,誠愿與各界朋友攜手奮進,共創繁榮。

D88尊龙Our company will abide by the commercial reputation and the principle of equality and mutual benefit, we sincerely provide users with the most excellent service to create a more perfect work, sincere hope and friends from all walks of life hand in hand advances boldly, create prosperity. 


上一篇:天然氣發電機組油箱的安裝方式
下一篇:夏季保養沼氣發電機組的注意事項