D88尊龙

你好,歡迎來到濟南D88尊龙環能燃氣發電設備有限公司官方網站!

燃氣發電機組啟動后轉速使用注意

來源:http://dgxcbw.comD88尊龙   發布于:2017-07-14

D88尊龙燃氣發電機組使用中需要注意事項:

Attentions to be used in gas generator set:

1、機房應遠離明火區域;

1, the engine room should be far away from the open flame area;

2、機房應寬敞、明亮且要求安裝換氣扇保證良通風;

D88尊龙2, the room should be spacious, bright and ensure good ventilation fan installation requirements;

3、產品安裝底盤與基應用平墊鐵找平接觸面積應60%且布均勻;

D88尊龙3, product installation chassis and base application pad, iron leveling contact area should be 60% and cloth evenly;

D88尊龙4、室內安裝照明、關、線路及其電器應采用防爆措施,且固定牢固;

D88尊龙4, indoor installation lighting, customs, wiring and electrical appliances should be explosion-proof measures, and fixed firm;

燃氣發電機組

D88尊龙5、燃氣發電機組機房內應符合消防要求配備滅火器等消防器械;

5, gas generator room should comply with fire requirements, equipped with fire extinguishers and other fire appliances;

D88尊龙6、燃氣發電機組機房內安裝燃氣體報警裝置燃氣體泄露能及發現;

D88尊龙6, gas generator room installed gas alarm device, gas leakage, energy and discovery;

7、60kw單臺燃氣發機燃氣管路外部主要管道內徑應于2吋靠近發機部內徑應于1吋60kw燃氣發電機組則別3吋兩吋且必須安裝燃氣閥門、型放水閥、防火裝置燃氣管路焊接完應清理焊渣。

D88尊龙7, 60kW single gas engine gas pipeline outside the main pipe diameter should be 2 inches in diameter should be close to the machine, 1 inch 60kW gas turbines are not 3 inches two inches and must be installed in the gas valve, drain valve, fire protection device type gas pipeline welding end should clean welding slag.

燃氣發電機組啟動后轉速升不上去:

After the gas generator starts, the speed can not rise:

1、燃料氣壓力低或預燃室閥不工作。檢查燃料氣壓力及閥門開度,如果壓力低,緩慢提高壓力;如果壓力正常,檢查預燃室電磁閥的工作及系統管路漏失情況。

1, the fuel gas pressure is low or the precombustion chamber valve does not work. Check the fuel gas pressure and valve opening, if the pressure is low, slowly increasing the pressure; if the pressure is normal, and the pipeline inspection system precombustion chamber solenoid valve leakage situation.

2、空氣量不夠。檢查空氣濾清器的進出壓差,如果超標,需更換濾芯。檢查空氣管路漏失情況。檢查渦輪增壓器轉子運轉情況。

D88尊龙2, the amount of air is not enough. Check air filter inlet and outlet pressure difference, if exceed standard, need to change filter core. Check air pipe leakage. Check the operation of the turbocharger rotor.

3、調速器不工作。調速器不動作的原因是混合器蝶閥開度不夠,調整或更換。

D88尊龙3 、 governor does not work. The governor does not move because the butterfly valve of the mixer is not open enough to adjust or replace.

4、動力缸溫差大,多個缸不點火。清潔火花塞及點火線圈,保證氣體干燥并接觸良好。檢查預燃室進氣閥的工作情況,清除積炭,使閥芯開閉靈活。

4 、 the temperature difference between the power cylinder is large, and the multiple cylinders do not ignite. Clean spark plugs and ignition coils to keep the gas dry and in good contact. Work, check the precombustion chamber of the intake valve to remove coke, so that the valve opening and closing flexible.

5、空燃比控制閥步進電機發卡。切斷電源,將其拆下清潔。然后裝好線束,送電檢查其工作情況,調整正常后將其裝回。

5, air fuel ratio control valve, stepper motor card. Cut off the power supply and clean it. Then install the wiring harness, send the electricity, check its work, adjust the normal, and install it back.

D88尊龙6、混合器故障。混合器漏失或閥芯膜片破損或造成閥芯無法正常工作,影響燃料氣的供給。整漏,清潔閥芯以及檢查膜片燃氣發電機組。

6 mixer malfunction. Mixer leakage or spool diaphragm damage or spool valve can not work properly, affecting the supply of fuel gas. Whole leakage, cleaning valve core and checking diaphragm gas generator set.

我們擁有嚴謹的工作態度,熟練的工作技能,將確保任務準確、的完成。

We have a strict work attitude, skilled work skills, will ensure that the task is accurate and efficient completion.


上一篇:瓦斯發電機組空氣濾清器
下一篇:變速箱油的作用及不按時換油的危害