D88尊龙

你好,歡迎來到濟南D88尊龙環能燃氣發電設備有限公司官方網站!

D88尊龙柴油發電機組使用注意事項

來源:http://dgxcbw.com   發布于:2016-12-19

  柴油發電機組D88尊龙也屬于機械設備,不管什么設備在使用前需要詳細的了解設備的工作狀態及知識,所以在操作前需要看產品使用說明書,結合說明來操作就會更加快速的掌握,但是說一句實話需要把那么厚的書本看完確實需要一定的耐心和毅力,其實一般書本上面有很多的都是理論的知識,只需要了解就行了,一些操作的常識是需要熟練掌握的,因為這個會直接影響到你自身的操作,下面我們就把柴油發電機組在使用中需要注意的事項給大家說一下:

  Diesel generator also belongs to the mechanical equipment, working condition and knowledge no matter what equipment before use requires detailed understanding of the equipment, so the need to look at the product instructions before operation, with instructions to operate will master more quickly, but to tell the truth to the thick book reading requires some patience and perseverance to do in fact, there are a lot of books in general are theoretical knowledge, only need to know on the line, some common sense is to master, because this will directly affect your own operation, we put the items under the diesel generator needs to pay attention in the use of to tell you:

D88尊龙  1、用戶在第一次使用機器前還是需要大致的看一下使用說明書以及保養手冊進行大致的了解。

D88尊龙  1, the user in the first use of the machine before or need to look at the use manual and maintenance manual for general understanding.

  2、機組在第一次運行50小時后需要對機器進行第一次的保養,也就是首保,保養包括機油,機油濾清器,柴油濾清器等。

D88尊龙  2, the unit in the first run 50 hours after the need for the first time the machine maintenance, that is, the first insurance, maintenance including oil, oil filters, diesel filters, etc.

  3、柴油發電機組應該在通風良好的環境下運行,避免廢氣和煙霧在操作間內不能排出,還有通風不暢會造成機器的溫升。

D88尊龙  3, diesel generator set should run in a well ventilated environment, to avoid exhaust gas and smoke in the operating room can not be discharged, as well as poor ventilation will cause the machine temperature rise.

D88尊龙  4、請在給水箱加水時選擇軟水或者防凍液,當環境溫度低于5℃時,應換成防凍液,或者放干凈水箱、缸體內和機油冷卻器內的水。

D88尊龙  4, please choose soft water or antifreeze in to the tank water, when the environment temperature is below 5 DEG C, should be replaced by antifreeze, or put a clean water tank, cylinder and oil cooler in the water.

  5、往柴油機內加燃油和機油時,需要選用規定牌號并采用專用的清潔容器。燃油需要經過沉淀72小時后加入油箱,在加入油箱時需要有濾網過濾。

D88尊龙  5, to the diesel engine with fuel and oil, the need to use the provisions of the brand and the use of special cleaning containers. The fuel needs to be added to the tank after 72 hours of settling.

  6、禁止無空氣濾清器的情況下使用,防止空間未經過過濾進入汽缸。

D88尊龙  6, prohibit the use of no air filter to prevent space without filtering into the cylinder.

  7、啟動前需要檢查機油位,水位,以及電氣連接線有無松動。

  7, before starting to check the oil level and water level, and the electrical connection line is loose.

  8、柴油發電機組在冷機啟動后不能立馬就轉高速,需要怠速運行一會然后在轉到高速運轉,這樣也有利于機械的磨合,切記不要長時間空轉。

D88尊龙  8, diesel generator set in cold start can not immediately turn to high speed, idle running for a while and then go to the high-speed operation, this is also conducive to the machine running, remember not long time idling.

  9、柴油發電機組額功率需要按照標定的功率運行不能超過,超過會造成設備的損壞。

  9, diesel generator set power required in accordance with the rated power operation can not exceed, more than will cause equipment damage.

  10、機器在運行過程中,需要間隔一段時間就需要在機器旁邊轉一圈,首頁是聽機器的工作狀態是否正常有無異響,其次是需要檢查水位,以及發電電壓和頻率的參數是否有變化。

D88尊龙  10, the machine in the operation process, need after a period of time will need to turn a circle in the side of the machine, the home page is listening to the working state of the machine is normal with abnormal sound, followed by the need to check the water level, and the parameters of the power voltage and frequency is changing.

D88尊龙  11、停機后,長時間不使用需要卸掉電瓶線。

  11, shutdown, long time no need to remove the battery line.

D88尊龙  以上就是在正常使用柴油發電機組中需要注意的一些事項,機械設備需要經常性的觀察運行狀態以及使用情況,所以有些是必須需要做的,希望引起大家的注意,做好這些可以有效的減少柴油發電機組的使用故障率,降低使用成本,提高使用效率。

  Some of the issues above is the need to pay attention to in the normal use of diesel generator, mechanical equipment need to observe the operation status and regular usage, so there is need to do, hope to attract everyone's attention, do these failures can effectively reduce the diesel generator set rate, reduce the use of cost, improve the efficiency of the use of.


上一篇:沼氣發電機組的使用性能及特點
下一篇:燃氣發電機組的發動機的起動注意事項